Kawi2strokes.com Forum
http://www.kawi2strokes.com/forum/

Deer camp DT going back together.
http://www.kawi2strokes.com/forum/viewtopic.php?f=11&t=10504		 Page 1 of 1
Author:  evansje1 [ Mon May 18, 2015 11:55 pm ]
Post subject:  Deer camp DT going back together.
Hey Jim,

The engine cases went back together pretty well.

Image

Image

Image

Image
Author:  Jim [ Tue May 19, 2015 8:13 am ]
Post subject:  Re: Deer camp DT going back together.
Nice. It looks familiar alright. Does the crank spin freely? I had that gasket/no-gasket confusion that slowed me down a little.
Author:  evansje1 [ Tue May 19, 2015 9:06 am ]
Post subject:  Re: Deer camp DT going back together.
Yes, everything fit back nice and the crankshaft is free. This engine did not have a gasket between the cases.

I doubt I have it running before my big event next week but that will give me something to look forward to after sitting around the house for a few weeks.
Author:  evansje1 [ Fri May 22, 2015 10:23 pm ]
Post subject:  Re: Deer camp DT going back together.
Failed the leak test. I'd damaged the stator side crank seal during it's installation. I'd chamfered the case as Ayor's crank seal replacement video shows for a triple but I had to rechamfer it to a much more gradual angle to get the seal to start. Clutch side went in easy but the stator side was a pain. Why is that seal such a pain to get started? The intake manifold surface also leaked but a little threebond took care of that.

Finally got it pass the leak test.

Image
Author:  Jim [ Fri May 22, 2015 11:05 pm ]
Post subject:  Re: Deer camp DT going back together.
Nice work, John, but with the stock port timing I don't think you need to bother installing any seals. :lol:
Author:  evansje1 [ Sat May 23, 2015 12:04 am ]
Post subject:  Re: Deer camp DT going back together.
My son Ben and I were stopped at the overlook when you and Aylor took off on your scoots and were whipping their A$$es. Ben laughed and said you guys reminded him of Dumb and Dumber :D :P

http://youtu.be/WFTZmECTVbs
Author:  Ja-Moo [ Sat May 23, 2015 12:23 am ]
Post subject:  Re: Deer camp DT going back together.
Smart, and smarter! ;) :lol: :lol: :lol:
Author:  evansje1 [ Mon May 25, 2015 8:01 pm ]
Post subject:  Re: Deer camp DT going back together.
I was really wanting to hear the engine run before tomorrow, but the primary coil winding is open :roll: so it will have to wait until I get healed up from the event tomorrow. I did have a new seat cover to put on so I got that done. I found the tool kit under the seat. Looks like the kit had never been opened.

I found out I'm better at putting on seat covers than putting in crankshaft seals ;)

Image

Image
Page 1 of 1 All times are UTC - 5 hours
Powered by phpBB® Forum Software © phpBB Group
http://www.phpbb.com/